Sportmat MSDS

MATERIAL SAFETY DATA SHEET

Product Name: SPORT MAT

Date Revised: 3/28/96 All Colors
Supersedes: 1/17/94

I. GENERAL INFORMATION******************************************************
MANUFACTURER: MANUFACTURER: Neyra Industries, Inc.
ADDRESS: 10700 Evendale Dr. Cincinnati, OH 45241
TELEPHONE #: (513) 733-1000 - CHEMTREC PHONE #: 1-800-424-9300
DOT SHIPPING NAME: Not Regulated
DOT HAZARD CLASSIFICATION: Not Regulated

	H	F	R	P			H	F	R	S
HMIS CODES:	1	0	0	B		NFPA CODES:	1	0	0	-

II. HAZARDOUS COMPONENTS**************************************************

COMPONENT	CAS#	% BY WT	TLV
Acrylic Copolymer Emulsion		< 30	N/D*
Ethylene Glycol#	107-21-1	< 2	50 ppm Ceiling
Zinc Oxide#	1314-13-2	< 4	5.0 mg/m³ fume
Chrome Oxide#@	1308-38-9	< 3	1 mg/m³ 8 hr.TWA
Calcium Carbonate	1317-65-3	< 6	10 mg/m³ total dust
Diatomaceous Earth	61790-53-2	< 2	10 mg/m³ total dust
Mica	12001-26-2	< 2	3 mg/m³ respirable
Silica Sand	14808-60-7	< 15	0.1 mg/m³**

* N/D = Not Determined
# Denotes toxic chemicals subject to the reporting requirements of Section 313 of SARA Title III.
@ Chrome Oxide in Sport Mat Green only.
** Respirable Crystalline Quartz

III. PHYSICAL DATA*************************************************************

APPEARANCE AND ODOR:

APPEARANCE AND ODOR: Colored liquid with a sweet, pine scent.
BOILING POINT: Approximately 212^oF
VAPOR PRESSURE: N/D
SPECIFIC GRAVITY: 1.15-1.20 (water = 1)
PERCENT VOLATILES: 46% by wt. max.
EVAPORATION RATE: < 1 (ethyl ether = 1)
SOLUBILITY IN WATER: Completely dispersible

IV. FIRE AND EXPLOSION HAZARD INFORMATION********************************

FLASH POINT:

FLASH POINT: N/D
EXPLOSIVE LIMIT: None
EXTINGUISHING MEDIA: Water fog, CO₂, Foam, Dry Chemical
SPECIAL FIREFIGHTING PROCEDURES/HAZARDS: Water cool sealed containers in area of fire to prevent rupture due to steam generation. Avoid breathing vapors. Self contained breathing equipment should be used in fighting fires involving chemicals.

V. REACTIVITY DATA************************************************************

STABILITY:

STABILITY: Stable
HAZARDOUS POLYMERIZATION: Will not occur
INCOMPATIBILITY/MATERIALS TO AVOID: This material reacts violently with any material that reacts violently with water such as concentrated sulfuric acid, sodium, potassium, calcium carbide, etc.
CONDITIONS TO AVOID: Do not allow to freeze. Do not store at temperatures above 200^oF.
HAZARDOUS DECOMPOSITION BYPRODUCTS: When the polymer burns, water, carbon dioxide, carbon monoxide, hydrogen chloride, and smoke can be produced.

VI. HEALTH HAZARD DATA******************************************************

PEL (FOR PRODUCT):

PEL (FOR PRODUCT): N/D
TLV (FOR PRODUCT): N/D
PRIMARY ROUTES OF ENTRY, SYMPTOMS OF EXPOSURE, FIRST AID:
EYES: May cause minor irritation. Flush eyes for fifteen minutes with clean water. See a doctor if irritation persists.
SKIN: No evidence of irritant properties. Wash from skin with soap and water.
INHALATION: Harmful effects not expected. For overexposure, move to fresh air.
INGESTION: Small amounts ingested should not be harmful. Treat symptomatically and see a doctor.
CONDITIONS AGGRAVATED BY EXPOSURE AND ADDITIONAL HEALTH HAZARDS: No conditions known to be aggravated by exposure to this product. Respirable crystalline quartz has been found to be a suspected carcinogen by NTP, although no exposure is expected through use of this material. This material has not been tested in long term, chronic exposure tests.

VII. SPILL RESPONSE AND ENVIRONMENTAL PROTECTION**********************

SPILL RESPONSE:

SPILL RESPONSE: Contain spill to limit it's spread. Mop up or absorb on inert material and place in containers. Do not flush into sewers or bodies of water.
WASTE DISPOSAL: If liquid, place in settling pond or solidify by other means. If dry, dispose of in an approved landfill or incinerate. Disposal to be in accordance with federal, state, and local regulations.

VIII. PROTECTIVE EQUIPMENT AND PROCEDURES*******************************

EYE PROTECTION:

EYE PROTECTION: Safety glasses or goggles recommended.
SKIN PROTECTION: Rubber gloves, long pants, long sleeve shirts.
RESPIRATORY PROTECTION: Not normally needed.
OTHER PROTECTIVE PROCEDURES: Use under well ventilated conditions. Exercise good personal hygiene when working with this material.

IX. SPECIAL PRECAUTIONS AND OTHER COMMENTS****************************

No special labeling is required. Store in a cool place, avoid freezing, and minimize contact with air to prevent contamination with bacteria. Drill a hole in bottom of empty pails to prevent drowning of small children.

The information contained herein is believed to be accurate but is not warranted to be whether originating with Neyra Industries or not. Users are advised to confirm in advance that the information is current, applicable, and suitable to their needs.

[Home] [Products] [MSDS] [Contact Us]